14kg鎂陽極保護年限20年詳情請咨詢
犧牲陽極填包料有用袋裝和現場鉆孔中填裝兩種方法,留意袋裝的袋子必需是自然纖維織品,嚴禁使用化纖織物。
犧牲陽極的分布可采用單支或集中成組兩種方式,陽極埋設分為立式,水平式兩種,埋設方向有軸向和徑向。成組埋設時,陽極間距2～3m為宜。對化學填包料的基本要求有：
?、?陽極地床構造
（泥土環境）
陽極安裝方式
14kg鎂陽極保護年限20年詳情請咨詢犧牲陽極組在管道上的間距,對于長輸管道為1 ～2組/km,對于城市管道及站內管網以200～300組為宜。常用填包料配方見附表：
為保證犧牲陽極在泥土中機能不亂,陽極周圍要填充適當?shù)幕瘜W(xué)填包料,陽極與泥土相鄰為陽極與填料相鄰,改善了陽極的工作環境；降低陽極接地電阻,增加陽極輸出電流；填料的化學成份有利陽極產物的溶解,不結痂,減少不必要的陽極極化；維持陽極地床長期潮濕。 rj2098555
⑵陽極地床的布置
14kg鎂陽極保護年限20年詳情請咨詢電阻率低,滲透滲出性好,不易流失；保濕性好。陽極埋設位置一般距管道外壁3～５m,小不宜小于0.3m,埋設深度以陽極頂部距地面不宜小于1m為宜,對于北方地區,必需在凍土層以下?，F(xiàn)場鉆孔填裝效果雖好,但填料用量要大,稍不留意輕易把土粒帶入填料中,影響填包的質量,填包料的厚度應在各個方向均保持5～10cm。在地下水位低于3m的干燥地帶,犧牲陽極應加深埋設,對河流,湖泊地帶,犧牲陽極應盡可能埋設在河床（湖底）的安全部位以防洪水沖涮和挖泥清淤時損壞。在城市和管網區使用犧牲陽極時,要留意陽極和被保護構筑物之間不應有其它構筑物,如電纜,水,汽,管道等。
The ribbon magnesium alloy sacrificial anode provided by our company has negative potential of magnesium anode, which produces large amount of electricity per unit mass. It is an ideal sacrificial anode material. It is applied to cathodic protection of metal structures in soil, fresh water and sea water. The magnesium alloy sacrificial anode is produced according to the national standard GB/T17731-2004 magnesium alloy sacrificial anode, and the anode used in the pipeline conforms to the SY/T0019-97 "design specification for the cathodic protection of the buried steel pipe sacrificial anode".
Mainly used for high resistivity environment, casing pipe protection, pipeline temporary cathodic protection, storage tanks and pipeline network protection, strong electrical interference protection of the grid. The chemical composition of magnesium strip anode Al Zn Mn Fe Ni Cu Si Mg Mg-I < 0.010 < 0.010 < 0.030 < 0.002 < 0.001 < 0.001 < 0.010 > 99.95 TD Mg-II < 0.010 ~ 0.50-1.30 < 0.03 < 0.001 < 0.02 - allowance. 4A/m soil (5000 ohm. Cm) 10mA/m fresh water (15000 ohm. Cm) 3mA/m
鎂陽極做成帶有鋼芯或做成可承重的鋼芯部件的長棒形，鋼芯可以穿過整根棒，也可以穿進一端。它們可以澆鑄做成，也可以采用擠壓工藝制成。它們的主要用途是土壤中埋地構筑物的防護和儲罐的內防護。陽極棒的粗細差別很大，可以做成細絲狀，也可以是直徑70mm的棒，單根陽極長1.5mm,陽極質量取決于合金